R901130814 PVQ1-1X/027LJ15DMB 力士乐叶片泵 叶片泵

REXROTH力士乐叶片泵
上海韦米机电设备有限公司供应力士乐Rexroth单向阀、Rexroth压力继电器、Rexroth方向阀、Rexroth溢流阀、
Rexroth电磁阀、Rexroth节流阀、液压阀、比例阀、比例液压阀、Rexroth 液压产品  Rexroth 静态配置液压阀、比例液压阀、液压阀、REXROTH液压阀力士乐0811系列、力士乐比例阀，比例流量阀 液压阀、叠加式节流阀 两路节流单向阀、力士乐压力指示单元、力士乐柱塞泵，叶片泵，外啮合齿轮泵-液压泵等供应，型号有4WE 、4WM 、DBD 、DR 、ZDB 、Z2FS 系列阀，A4V、A10VS0、A2FO系列柱塞泵，A2FE、A2FM液压马达，HED系列压力继电器。
“叶片泵不出油”几乎所有的故障原因均有可能是压力上不去或者根本无压力的原因：
1、配油盘与壳体端面（固定面）接触不良，之间有较大污物契入，使压油腔部分压力油通过两者之间的间隙流入低压区，输出减小，应拆开清洗，使之密合。
2、配油盘与转子贴合端面（滑动面）拉毛，磨损严重，内泄漏量大，输出不够，可先用较粗（不能太粗）的砂纸打磨拉毛高点，然后用细砂布磨掉凹痕，抛光后使用。
3、定子内孔（内曲线表面）拉毛，磨损，叶片圆与定子孔内曲面支架的拉毛划伤沟痕漏往吸油区，造成输出不够，可用金相砂纸磨砂定子内曲面。
4、叶片和后钻子组合件（泵芯）装反了
5、泵体有气孔，沙眼，缩松等铸造缺陷，被击穿，使高，低压腔局部连通，吸不上油，此时可能要换叶片泵。
6、轴向间隙太大，即叶片泵转子厚度与定子厚度和叶片泵泵体孔深度尺寸相差太大，或者修理时加了纸垫子，使轴向间隙过大，内泄漏过大，内泄漏，而使输出减小。
7、变量机构调的不对，或者有毛病，可在查明原因后酌情处理
8、配油盘端面磨损或拉有沟槽，内泄漏量大，输出 不够，一般要研磨配油盘端面。
9、滤油器堵塞，或过滤精度太高，不上油或上油很少（视堵塞程度而定），可拆卸清洗。
10、液压油的粘度过低，特别是对小容量叶片泵，当油液粘度过低或因油温温升过高，叶片泵打出的油往往不能加载上升到所需压力。这是油液粘度过低和温升造成内泄漏的缘故。
11、对限压式变量叶片泵，当压力调节螺钉未调好，过限压压力后，显著减小，进入系统后，压力难以高。
12、叶片泵内零件磨损后，在低温时虽可升压，但设备运转一段时间后，油温升高，因磨损产生的内泄漏大，压力损失也大，压力此时便上不去（不能到），如果此时想硬性调整上去（旋紧溢流阀），会产生表针剧烈抖动的现象。此时可以肯定是叶片泵内严重磨损，如果换一台新的叶片泵，压力马上会上去。
13、定子内表面刮伤，致使叶片部与定子内曲面接触不良，内泄漏大，减小，压力难以调上去。此时应抛光定子内曲线表面或者换定子。
14、对装有减压阀的中高压叶片泵，如果减压阀的输出压力调的太高，会导致叶片部与定子内表面因接触应力过大而早期磨损。使叶片泵内泄漏大，输出减小，压力也上不去。
除了容积式泵的一般特性之外，叶片泵还具有以下特征。
1.相对均匀，运行稳定，噪音小。
2.双作用叶片泵采用径向力平衡，轴承寿命长，内部密封性好，容积效率高，可用于高压应用。通常，叶片泵的额定工作压力不过7MPa，高压叶片泵可达到14-21MPa。
3.结构紧凑，体积小，大。
4.单作用叶片泵可实现可变方向可变调节。
5.工作条件加严格。由于叶片的抗冲击性差和易堵塞，它对油的清洁度和粘度敏感。还必须正确配置端部间隙或滑槽间隙。另外，当旋转速度太低时，叶片可能由于离心力不足而不能按压定子表面，并且如果太高，则可能发生空化。一般叶片泵的速度约为500~2000r/min。
6.结构复杂，零件的制造精度高。
在船舶中，叶片泵通常用作液压系统中的工作油泵或用作低粘度清洁油的泵。
上海韦米机电设备有限公司主营：Airtec爱尔泰克、ASCO、ATOS、 AVENTICS安沃驰、贝加莱（B&R）、Bently本特利、DUPLOMATIC迪普马、REXROTH力士乐、MOOG穆格、PARKER派克、VICKERS威格士、SIEMENS西门子、、、等
R901397744 PVV2-1X/045RJ15LMBK01
R900942298 PVV2-1X/045RJ15UMB
R978004983 PVV2-1X/045RJ15UMBK01
R978903858 PVV2-1X/045RR15DMB
R978905752 PVV2-1X/045RR15RMB
R978918795 PVV2-1X/045RR15UMB
R900939347 PVV2-1X/055LA15DMB
R900767420 PVV2-1X/055LA15UMB
R978907725 PVV2-1X/055LR15LMB
R900936290 PVV2-1X/055RA15DMB
R901031937 PVV2-1X/055RA15DVB
R901063622 PVV2-1X/055RA15LMB
R900941698 PVV2-1X/055RA15RMB
R900974346 PVV2-1X/055RA15RVB
R900928955 PVV2-1X/055RA15UMB
R900968642 PVV2-1X/055RA15UVB
R900943199 PVV2-1X/055RB15DMB
R900761013 PVV2-1X/055RB15DMBK01
R987072223 PVV2-1X/055RB15DMBK01+PGH3-2X/011RR07MU2
R900761014 PVV2-1X/055RB15DMBK02
R901349896 PVV2-1X/055RB15UMBK02
R900966041 PVV2-1X/055RJ15DMB
R901363064 PVV2-1X/055RJ15DVB
R978027081 PVV2-1X/055RJ15LMB
R978045700 PVV2-1X/055RJ15LVB
R901147098 PVV2-1X/055RJ15RMB
R901404958 PVV2-1X/055RJ15UEB
R900940446 PVV2-1X/055RJ15UMB
R987110990 PVV2-1X/055RJ15UVB
R978903559 PVV2-1X/055RR15DMB
R978919563 PVV2-1X/055RR15LMB
R900753121 PVV2-1X/060LA15DMB
R900958917 PVV2-1X/060LA15LVB
R900968076 PVV2-1X/060LA15UMB
R978031641 PVV2-1X/060LA15UVB
R900936197 PVV2-1X/060RA15DMB
R900974043 PVV2-1X/060RA15DVB
R901091909 PVV2-1X/060RA15LMB
R988004371 PVV2-1X/060RA15LMB
R978006885 PVV2-1X/060RA15LVB
R900949069 PVV2-1X/060RA15RMB
R900705785 PVV2-1X/060RA15RVB
R900941572 PVV2-1X/060RA15UMB
R988004372 PVV2-1X/060RA15UMB
R900784970 PVV2-1X/060RA15UVB
R900940215 PVV2-1X/060RB15DMB
R900761015 PVV2-1X/060RB15DMBK01
R900761016 PVV2-1X/060RB15DMBK02
R978919622 PVV2-1X/060RB15LMB
R900753479 PVV2-1X/060RB15LMBK01
R987074002 PVV2-1X/060RB15LMBK01+PGP2-2X/006RJ20VU2
R978904925 PVV2-1X/060RB15UMB
R900704432 PVV2-1X/060RJ15DMB
R901148815 PVV2-1X/060RJ15DMB-A462
R901349605 PVV2-1X/060RJ15DVB
R900249167 PVV2-1X/060RJ15LMB
R901025811 PVV2-1X/060RJ15UMB
R978004984 PVV2-1X/060RJ15UMBK01
R978917771 PVV2-1X/060RR15RMB
R978907371 PVV2-1X/060RR15UMB

R900776736 PV7-1X/40-71RE37MC0-08-A184
R901320923 PV7-1X/40-71RE37MC0-08-A474
R987124720 PV7-1X/40-71RE37MC008+PGH2-2X/006RR07VU2
R900561581 PV7-1X/40-71RE37MC3-08
R900539468 PV7-1X/40-71RE37MC5-08
R900958545 PV7-1X/40-71RE37MC5-08-A234
R901197066 PV7-1X/40-71RE37MC5-08WG
R900711250 PV7-1X/40-71RE37MC5-08WH
R900719062 PV7-1X/40-71RE37MC7-08
R900751358 PV7-1X/40-71RE37MC7-08WG
R901163657 PV7-1X/40-71RE37MC7-08WH
R987064864 PV7-1X/40-71RE37MCO08+V7-1X/10-14RE01MC
R900539886 PV7-1X/40-71RE37MD0-08
R976718445 PV7-1X/40-71RE37MD0-08-A427
R901059512 PV7-1X/40-71RE37MW0-08WH
R987065694 PV7-1X/40-71REMCO08+ PV7-40-45RE37MCO16
R900506808 PV7-1X/63-71RE07MC0-16
R987218893 PV7-1X/63-71RE07MC0-16LIM50CC/G
R987073484 PV7-1X/63-71RE07MC0-16LIM.A60CC/G
R987243968 PV7-1X/63-71RE07MC0-16-Q=90L.1750G.
R987063402 PV7-1X/63-71RE07MC0-1680L/1'-65BAR
R987046385 PV7-1X/63-71RE07MC0-16LIM.75L.1450
R987066973 PV7-1X/63-71RE07MC0-16TARATAA56CC;
R987071429 PV7-1X/63-71RE07MC0-16TARATAA62CC
R987070973 PV7-1X/63-71RE07MC0-16+GH2-2X/006RR07MU2
R987073849 PV7-1X/63-71RE07MC0-16+PGH3-2X016RR07VU2
R987067590 PV7-1X/63-71RE07MC0-16+PVV1-027RJ15DMB
R900720730 PV7-1X/63-71RE07MC0-16-A234
R901443119 PV7-1X/63-71RE07MC0-16-C3.1
R900511986 PV7-1X/63-71RE07MC3-16
R900518218 PV7-1X/63-71RE07MC5-16
R900553692 PV7-1X/63-71RE07MC5-16WG
R900942455 PV7-1X/63-71RE07MC5-16WH
R900976100 PV7-1X/63-71RE07MC6-16
R900535061 PV7-1X/63-71RE07MC7-16
R900705106 PV7-1X/63-71RE07MC7-16WH
R900519094 PV7-1X/63-71RE07MD0-16
R900925956 PV7-1X/63-71RE07MD0-16-A234
R901400158 PV7-1X/63-71RE07MD0-16-Q90
R900910480 PV7-1X/63-71RE07MD5-16
R900750169 PV7-1X/63-71RE07MD6-16
R900744715 PV7-1X/63-71RE07MN0-16
R900733271 PV7-1X/63-71RE07MW0-16
R901151476 PV7-1X/63-71RE07MW0-16WG
R901017159 PV7-1X/63-71RE07MW0-16WH
R901119795 PV7-1X/63-71RE07MW5-16WH
R900560659 PV7-1X/63-94RE07MC0-08
R901416893 PV7-1X/63-94RE07MC0-08-P50Q116
R901365507 PV7-1X/63-94RE07MC0-08-P75
R901411968 PV7-1X/63-94RE07MC0-08-P80Q114

R901410760 PV7-1X/06-14RA01MA0-04-P30Q19
R900919237 PV7-1X/06-14RA01MA0-07
R983035246 PV7-1X/06-14RA01MA0-07IN010
R901224086 PV7-1X/06-14RA01MA0-07-P50
R901239010 PV7-1X/06-14RA01MA0-07-P65
R901276189 PV7-1X/06-14RA01MA0-07-P70
R901390004 PV7-1X/06-14RA01MA0-07-P70Q18
R900979156 PV7-1X/06-14RA01MA0-10-A410
R901081778 PV7-1X/06-14RA01MA0-10-A452
R901235918 PV7-1X/06-14RA01MA0-10-A473
R901267598 PV7-1X/06-14RA01MA0-10-A492
R900951588 PV7-1X/06-14RA01MA3-04
R900952282 PV7-1X/06-14RA01MA3-07
R987065613 PV7-1X/06-14RA01MAO-07LIMIT.A12CC
R900950952 PV7-2X/20-20RA01MA0-05
R901464459 PV7-2X/20-20RA01MA0-05-P25
R901364572 PV7-2X/20-20RA01MA0-05-P50
R900950953 PV7-2X/20-20RA01MA0-10
R900618143 PV7-2X/20-20RA01MA0-10-A416
R901396092 PV7-2X/20-20RA01MA0-10-C3.1
R901276787 PV7-2X/20-20RA01MA0-10-P100
R901242257 PV7-2X/20-20RA01MA0-10-P65
R901253811 PV7-2X/20-20RA01MA0-10-P85
R900755261 PV7-2X/20-20RA01MA3-05
R900749846 PV7-2X/20-20RA01MA3-10
R900950954 PV7-2X/20-25RA01MA0-05
R983035244 PV7-2X/20-25RA01MA0-05IN010
R901441616 PV7-2X/20-25RA01MA0-05-P24Q30
R901410778 PV7-2X/20-25RA01MA0-05-P30Q25
R901428736 PV7-2X/20-25RA01MA0-05-P30Q36
R901412012 PV7-2X/20-25RA01MA0-05-P45Q35
R901410767 PV7-2X/20-25RA01MA0-05-P45Q36
R901416531 PV7-2X/20-25RA01MA0-05-P50
R900950955 PV7-2X/20-25RA01MA0-10
R983035245 PV7-2X/20-25RA01MA0-10IN010
R901410776 PV7-2X/20-25RA01MA0-10-P63Q35
R900741427 PV7-2X/20-25RA01MA3-05
R900704549 PV7-2X/20-25RA01MA3-10
R987065612 PV7-2X/20-25RA01MAO-10LIMIT.A16CC
R987065360 PV7-2X/20-25RA01MAO-10LIMIT.A19CM3
R987065489 PV7-2X/20-25RA01MAO-10LIMIT.A25CM3
R987324602 PVV21-1X/060-008RA15DRMB
R902650898 PVV51-1X/139-018RJ15DLMC
R900944816 PVV1-1X/018LA15DMB
R900963900 PVV1-1X/018LA15UMB
R978910809 PVV1-1X/018LR15UMB
R900942114 PVV1-1X/018RA15DMB
R978903563 PVV1-1X/018RA15DMBSO43A-1500
R978910143 PVV1-1X/018RA15LMB
R901037970 PVV1-1X/018RA15RMB

以下是本公司常用德国博世REXROTH力士乐公司旗下进口叶片泵的部分型号：
REXROTH力士乐叶片泵
R901320916 PV7-1X/10-14RE01MC0-08-A474
R900580381 PV7-1X/10-14RE01MC0-16
R987046360 PV7-1X/10-14RE01MC0-16LIM.15LT1450G.
R987047421 PV7-1X/10-14RE01MC0-16LIM.16LT/MIN
R987065905 PV7-1X/10-14RE01MC0-16+ZFS11/22,5R213
R987072161 PV7-1X/10-14RE01MC0-16+ZFS11/8R213
R900533851 PV7-1X/10-14RE01MC0-16-A184
R901358374 PV7-1X/10-14RE01MC0-16-P100
R901382678 PV7-1X/10-14RE01MC0-16-P125Q8
R901171150 PV7-1X/10-14RE01MC0-16-P140Q10
R900941071 PV7-1X/10-14RE01MC0-16-P45
R900941073 PV7-1X/10-14RE01MC0-16-P60Q15
R901442350 PV7-1X/10-14RE01MC0-16-P60Q20
R901414295 PV7-1X/10-14RE01MC0-16-P80Q20
R901344755 PV7-1X/10-14RE01MC0-16-P90
R900598753 PV7-1X/10-14RE01MC3-16
R900520401 PV7-1X/10-14RE01MC5-16
R901394361 PV7-1X/10-14RE01MC5-16WG
R900933324 PV7-1X/10-14RE01MC5-16WH
R901010430 PV7-1X/10-14RE01MC6-16
R900509053 PV7-1X/10-14RE01MC7-16
R900504653 PV7-1X/10-14RE01MD0-16
R900548512 PV7-1X/10-14RE01MD0-16-A234
R901404893 PV7-1X/10-14RE01MD0-16-Q15
R900520725 PV7-1X/10-14RE01MD3-16
R900520787 PV7-1X/10-14RE01MD5-16
R900537419 PV7-1X/10-14RE01MN0-16
R900772792 PV7-1X/10-14RE01MW0-16
R901136642 PV7-1X/10-14RE01MW0-16WG
R900741002 PV7-1X/10-14RE01MW0-16WH
R900534143 PV7-1X/10-20RE01MC0-10
R987179771 PV7-1X/10-20RE01MC0-10HAMERSLAGGRIJS
R901292147 PV7-1X/10-20RE01MC0-10-A497
R901388556 PV7-1X/10-20RE01MC0-10-P30Q25
R900941072 PV7-1X/10-20RE01MC0-10-P45
R901404630 PV7-1X/10-20RE01MC0-10-P70Q28
R987067707 PV7-1X/10-20RE01MC010+1PF2G2-4X/08RR20MR
R987074006 PV7-1X/10-20RE01MC010+AZPF-11-008RRR20MB
R987136850 PV7-1X/10-20RE01MC010+R4/1,00-450WG01M01
R900538125 PV7-1X/10-20RE01MC3-10
R901303349 PV7-1X/10-20RE01MC3-10-A497
R900539710 PV7-1X/10-20RE01MC5-10
R900738663 PV7-1X/10-20RE01MC5-10WG
R900247239 PV7-1X/10-20RE01MC5-10WH
R900908540 PV7-1X/10-20RE01MC7-10
R900931507 PV7-1X/10-20RE01MC7-10WH
R900906584 PV7-1X/10-20RE01MD0-10
R900782498 PV7-1X/10-20RE01MD0-10-A234
R900700454 PV7-1X/10-20RE01MD5-10
R901043560 PV7-1X/10-20RE01MW0-10WH
R901339232 PVV52-1X/154-045RA15DDMC
R900963882 PVV52-1X/154-045RB15DDMC
R900939038 PVV52-1X/154-055RA15DDMC
R901089061 PVV52-1X/154-055RA15UUMC
R900939680 PVV52-1X/154-060RA15DDMC
R901223655 PVV52-1X/154-068RA15UUMC
R901085398 PVV52-1X/154-068RB15DDMC
R901404614 PVV52-1X/154-068RJ15UUMC
R987033235 PVV52-1X/154-55RJ15UUMC
R978913881 PVV52-1X/162-040RA15DDMC
R900973886 PVV52-1X/162-040RA15RDMC
R901357356 PVV52-1X/162-040RA15RUMC
R901002827 PVV52-1X/162-040RA15UUMC
R901412027 PVV52-1X/162-045RA15DDMC
R901381680 PVV52-1X/162-055RA15DDMC
R901255948 PVV52-1X/162-055RA15RDMC
R900728945 PVV52-1X/162-055RA15UDMC
R901276424 PVV52-1X/162-055RA15UUMC
R901085400 PVV52-1X/162-055RB15DDMC
R900738922 PVV52-1X/162-055RB15LLMC
R901014425 PVV52-1X/162-060RA15UUMC
R978910704 PVV52-1X/162-068RA15DDMC
R901002823 PVV52-1X/162-068RA15UUMC
R901007059 PVV52-1X/162-068RB15DDMC
R901247411 PVV52-1X/162-068RB15UUMC
R901294741 PVV52-1X/162-068RJ15UUMC
R901366321 PVV52-1X/183-045RA15UUMC
R900961567 PVV52-1X/183-055RB15DDMC
R900945122 PVV52-1X/183-055RB15DUMC
R900616634 PVV52-1X/183-055RB15LLMC
R900948956 PVV52-1X/183-060RA15DDMC
R900978474 PVV52-1X/183-060RA15UUMC
R901425928 PVV52-1X/183-060RB15DDMC
R900949677 PVV52-1X/183-068RA15DDMC
R978918407 PVV52-1X/183-068RA15RLMC
R900941695 PVV52-1X/193-040LA15DUMC
R978015393 PVV52-1X/193-040LA15UUMC
R901422095 PVV52-1X/193-040RA15DUMC
R978906600 PVV52-1X/193-040RB15URMC
R901008153 PVV52-1X/193-040RJ15UUMC
R901084887 PVV52-1X/193-045RA15DDMC
R900746742 PVV52-1X/193-045RA15URMC
R901020329 PVV52-1X/193-045RB15LLMC
R901186723 PVV52-1X/193-045RJ15UUMC
R900936930 PVV52-1X/193-055RA15DDMC
公司产品广泛应用于工程机械车辆,石油机械，煤矿掘进机，扒渣机，钻井机械，矿山机械，渔船，吊车，捣炉机等行业和领域.公司实行5S管理，高标准精细化管理，努力提高产品质量和质价比同时提供完善的服务。欢迎各界朋友莅临参观、和业务洽谈。
​业务专员：董玄​
本公司产品品种多，型号全，质量优，服务好，货期短如有询价、技术咨询、采购等需求请来电联系，上海韦米期待您的来电或上门拜访！真诚合作，竭诚为您服务！！！

上海韦米机电设备有限公司位于上海市浦东新区金桥禹洲，是一家从事经营国外进口液压气动备件、自动化仪表的贸易型公司；专注于中国工业传动自动化流体领域。主营产品电磁阀、柱塞泵、数控模块、伺服电机、可编程控制器、传感器、气动元件、工业仪器仪表等。经营有：博世力士乐rexroth、阿托斯ATOS、迪普马DUPLOMATIC、Parker派克、EATON VICKERS伊顿、贝加莱B&R、西门子Siemens低压、爱尔泰克Airtec气动等进口。 
     公司本着创业人为本、发展靠科技、管理出效益、信誉一、服务至上的理念。为广大的顾客设计 ，为企业设计效益 ，为社会设计财富 ，为员工设计机遇的发展方向 。我们的理念是让优秀的企业成为我们的客户，让我们的客户成为优秀的企业。公司不仅仅提供的销售服务，同时还建立了完善的售后服务体系，为企业发展中遇到的问题和困难提供指导帮助。我们相信，通过我们的不断努力和追求，一定能够实现与中小企业的互利共赢！ 
     我们热诚欢迎各界朋友来电咨询、实地考察、洽谈业务。